發電機和其他機器一樣，也需要經常維護。連續運行會使發電機的不同部分承受巨大的壓力。按照以下這些提示充分利用發電機并優化其運行時間，下面瓦斯發電機組廠家的為您講解五大技巧。

The generator, like other machines, also needs regular maintenance. Continuous operation will make different parts of the generator bear huge pressure. Follow these tips to make full use of the generator and optimize its running time. Here are five tips from the manufacturer of gas generator set.

1.檢查并加滿發動機油

1. Check and top up engine oil

發電機的發動機機油潤滑不同的部件，有助于減少因經常磨損而產生的摩擦。關閉發電機后，請務必用油尺檢查發電機的機油位。讓上部的機油流回曲軸箱。定期加注機油。定期更換機油和機油濾清器（通過您的用戶手冊了解制造商的說明）。選擇符合OEM通用潤滑油規格的潤滑油。

The engine oil of the generator lubricates different components, helping to reduce friction caused by frequent wear. After turning off the generator, be sure to check the oil level of the generator with the oil dipstick. Allow the upper oil to flow back to the crankcase. Fill oil regularly. Change the oil and oil filter regularly (read the manufacturer's instructions through your user manual). Select a lubricant that meets the OEM general lubricant specifications.

2.測試和清潔電池

2. Test and clean the battery

電池電量不足的發電機無法產生足夠的電力來滿足您的要求。電池須保持充滿電且維護良好。如果您的發電機沒有執行指示性測試來測量負載下的端電壓，請使用手動電池負載測試儀進行測試。用濕布清潔電池。如果您發現端子周圍有腐蝕跡象，請清潔它們。在開式鉛酸電池中，檢查每個電池中電解液的比重和電解液液位（每運行200小時）。

The generator with low battery power cannot generate enough power to meet your requirements. The battery must be kept fully charged and well maintained. If your generator does not perform an indicative test to measure the terminal voltage under load, use a manual battery load tester to test. Clean the battery with a damp cloth. If you find signs of corrosion around the terminals, clean them. In open lead acid batteries, check the specific gravity and electrolyte level of each battery (every 200 hours of operation).

3.檢查冷卻液液位

3. Check the coolant level

不時檢查瓦斯發電機組的冷卻液液位。添加冷卻液直到液位符合制造商要求的位置。如果您有重型發電機，請?zhí)砑永鋮s液添加劑、水和防凍劑的平衡混合物。用軟刷檢查和清潔散熱器的外部。小心避免損壞翅片，使用低壓壓縮空氣清潔散熱器。

Check the coolant level of gas generator set from time to time. Add coolant until the level meets the manufacturer's requirements. If you have a heavy-duty generator, add a balanced mixture of coolant additives, water, and antifreeze. Check and clean the outside of the radiator with a soft brush. Be careful not to damage the fins and clean the radiator with low pressure compressed air.

4.檢查不同的系統

4. Check different systems

會隨著時間的推移而受到污染。為避免由受污染的引起的腐蝕和其他問題，請定期排放燃油濾清器。定期檢查燃油系統和啟動系統等不同系統。檢查增壓空氣冷卻器管道和軟管是否有泄漏、裂縫和孔洞。修復排氣管周圍的泄漏（通常發生在墊圈、連接點和焊縫處）。

It will be polluted over time. To avoid corrosion and other problems caused by contamination, drain the fuel filter regularly. Regularly check different systems such as fuel system and starting system. Check the charge air cooler pipes and hoses for leaks, cracks and holes. Repair leaks around the exhaust pipe (usually at gaskets, connection points and welds).

5.清潔發電機

5. Clean the generator

瓦斯發電機組越清潔，就越容易維護它。修理損壞的軟管和皮帶。采取措施防止動物在發電機中筑巢，要始終保持發動機清潔。

The cleaner the gas generator set is, the easier it is to maintain it. Repair damaged hoses and belts. Take measures to prevent animals from nesting in the generator, and always keep the engine clean.

以上就是關于5大技巧助發電機持續運行并優化機運行時間的相關內容了，您可以看看作為參考信息使用，當然還是要結合自己的機器實際來做好維護。關注我們http://www.51credits.cn，了解更多事項！

The above is about the five skills to help the generator run continuously and optimize the running time of the machine. You can take a look at them as reference information. Of course, you should do a good job of maintenance according to your own machine reality. Follow us http://www.51credits.cn , learn more!